Evaluating organic acids as alternative leaching reagents for rare earth elements recovery from NdFeB magnets

This study proposes an advanced leaching method using organic acids to recover rare earth elements (REEs) from NdFeB permanent magnets from end-of-life computers hard disk drives (HDDs). The end-of-life HDDs were first dismantled in order to recover NdFeB magnets, which were then thermally demagnetized at 350 °C during 30 min before crushing in a ball mill under inert atmosphere. Scanning electron microscopy/energy dispersive X-ray spectroscopy (SEM/EDS) analyses performed on the NdFeB magnets show the heterogeneous structure containing the major matric phase Nd 2 Fe 14 B and the rich-REEs phase containing Nd and Pr oxides. Additionally, X-ray diffraction (XRD) and Mössbauer spectroscopy (MS) analyses on the ground NdFeB magnet show that grinding NdFeB magnets under inert atmosphere helps to minimize its oxidation. Chemical analysis shows that the composition of the ground sample is Nd: 22.8 wt%, Pr: 3.3 wt%, Dy: 1.2 wt%, Fe: 62.6 wt%, Co: 1.5 wt%, B: 0.9 wt%, Ni: 0.6 wt%. Diagrams of speciation and equilibrium phases (Eh vs. pH) were calculated to determine the predominance of the formed species in the REEs – organic acids systems. The influence of the organic acid type (acetic acid, formic acid, citric acid and tartaric acid), the acid concentration (10 vol%, up to saturation), and the solid/liquid (S/L) ratio (0.5%–10%) on NdFeB magnets leaching was investigated employing an optimal experimental design conceived by the statistical software JMP. Acetic acid (CH₃COOH) shows the highest leaching performance of REEs, allowing leaching yields over 90% for Nd, Dy and Pr in the acid concentration (mol/L) range of 1.6 – 10 and the S/L ratio (%) range of 0.5 – 5 using a temperature of 60 °C. The results presented in this investigation suggest that REEs can be recovered from magnets of end-of-life HDDs using an eco-friendly method assisted by organic acids. NdFeB permanent magnets were extracted from end-of-life hard disk drives, characterized, then ground under inert atmosphere. NdFeB magnets powder was then leached in organic acid solutions. Acetic acid was efficient to leach rare earth elements Nd, Pr and Dy. • NdFeB magnet from end-of-life computers hard disk drives (HDDs) have been characterized as part of their valuation. • Leaching of rare earth elements (REEs) from NdFeB powder was investigated using organic acids. • A multiparametric study was carried out based on the design of experiments (DoE) to model REEs leaching. • High leaching yields were obtained for Nd, Pr, and Dy in acetic acid.