Metabolic disturbances potentially attributable to clogging during continuous renal replacement therapy

Background Clogging is characterized by a progressive impairment of transmembrane patency in renal replacement devices and occurs due to obstruction of pores by unknown molecules. If citrate-based anti-coagulation is used, clogging can manifest as a metabolic alkalosis accompanied by hypernatremia and hypercalcemia, primarily a consequence of Na 3 Citrate infusion. An increased incidence of clogging has been observed during the COVID-19 pandemic. However, precise factors contributing to the formation remain uncertain. This investigation aimed to analyze its incidence and assessed time-varying trajectories of associated factors in critically ill patients on continuous renal replacement therapy (CRRT). Methods In this retrospective, single-center data analysis, we evaluated COVID-19 patients undergoing CRRT and admitted to critical care between March 2020 and December 2021. We assessed the proportional incidence of clogging surrogates in the overall population and subgroups based on the specific CRRT devices employed at our institution, including multiFiltrate (Fresenius Medical Care) and Prismaflex System (Baxter). Moderate and severe clogging were defined as Na > 145 or ≥ 150 mmol/l and HCO 3 − > 28.0 or ≥ 30 mmol/l, respectively, with a total albumin-corrected calcium > 2.54 mmol/l. A mixed effect model was introduced to investigate factors associated with development of clogging. Results Fifty-three patients with 240 CRRT runs were analyzed. Moderate and severe clogging occurred in 15% (8/53) and 19% (10/53) of patients, respectively. Twenty-seven percent (37/136) of CRRTs conducted with a multiFiltrate device met the criteria for clogging, whereas no clogging could be observed in patients dialyzed with the Prismaflex System. Occurrence of clogging was associated with elevated triglyceride plasma levels at filter start ( p = 0.013), amount of enteral nutrition ( p = 0.002) and an increasing white blood cell count over time ( p = 0.002). Conclusions Clogging seems to be a frequently observed phenomenon in critically ill COVID-19 patients. The presence of hypertriglyceridemia, combined with systemic inflammation, may facilitate the development of an impermeable secondary membrane within filters, thereby contributing to compromised membrane patency.