The engineering of a protein containing an alternative local residue packing for a set of side-chains has proven to be a major challenge because compositional, volumetric and steric constraints must be respected. Homologous proteins should provide examples of alternative groups of residues leading to a similar functional result. The functional significance of a pair of co-ordinated changes that are observed in the cysteine proteases family has been investigated by comparing the effect of individual or double changes on secretion, stability and activity of papain. The two changes are not independent. Detrimental effects of single mutations at one of the two positions can be partly suppressed by the co-ordinated mutation that reproduces naturally occurring contacts, indicating that these changes are concerted. Single mutations at the other position produce milder effects, suggesting a pathway for evolution.

The S2 subsite specificity of the plant protease papain has been altered to resemble that of mammalian cathepsin B by site-directed mutagenesis. On the basis of amino acid sequence alignments for papain and cathepsin B, a double mutant (Val133Ala/Ser205Glu) was produced where Val133 and Ser205 are replaced by Ala and Glu, respectively, as well as a triple mutant (Val133Ala/Val157Gly/Ser205Glu), where Val157 is also replaced by Gly. Three synthetic substrates were used for the kinetic characterization of the mutants, as well as wild-type papain and cathepsin B: CBZ-Phe-Arg-MCA, CBZ-Arg-Arg-MCA, and CBZ-Cit-Arg-MCA. The ratio of k(cat)/K(M) obtained by using CBZ-Phe-Arg-MCA as substrate over that obtained with CBZ-Arg-Arg-MCA is 8.0 for the Val133Ala/Ser205Glu variant, while the equivalent values for wild-type papain and cathepsin B are 904 and 3.6, respectively. This change in specificity has been achieved by replacing only two amino acids out of a total of 212 in papain and with little loss in overall enzyme activity. However, further replacement of Val157 by Gly as in Val133Ala/Val157Gly/Ser205Glu causes an important decrease in activity, although the enzyme still displays a cathepsin B like substrate specificity. In addition, the pH dependence of activity for the Val133Ala/Ser205Glu variant compares well with that of cathepsin B. In particular, the activity toward CBZ-Arg-Arg-MCA is modulated by a group with a pK(a) of 5.51, a behavior that is also encountered in the case of cathepsin B but is absent with papain. Results of this study suggest that sequence alignment of cysteine proteases coupled with the structural information that is available for papain can be used to achieve a better understanding of the molecular mechanism and specificity of structurally and functionally related cysteine proteases.

In a previous study, it was shown that replacing Asp158 in papain by Asn had little effect on activity and that the negatively charged carboxylate of Asp158 does not significantly stabilize the active site thiolate-imidazolium ion pair of papain (Ménard et al., 1990). In this paper, we report the kinetic characterization of three more mutants at this position: Asp158Gly, Asp158Ala, and Asp158Glu. From the pH-activity profiles of these and other mutants of papain, it has been possible to develop a model that enables us to dissect out the contribution of the various mutations toward (i) intrinsic activity, (ii) ion pair stability, and (iii) the electrostatic potential at the active site. Results obtained with mutants that place either Gly or Ala at position 158 indicate that the hydrogen bonds involving the side chain of Asp158 in wild-type papain are indirectly important for enzyme activity. When CBZ-Phe-Arg-MCA is used as a substrate, the (kcat/KM)obs values at pH 6.5 are 3650 and 494 M-1 s-1 for Asp158Gly and Asp158Ala, respectively, as compared to 119,000 M-1 s-1 for papain. Results with the Asp158Glu mutant suggest that the side chain of Glu moves closer to the active site and cannot form hydrogen bonds similar to those involving Asp158 in papain. From the four mutations introduced at position 158 in papain, we can conclude that it is not the charge but the hydrogen-bonding interactions involving the side chain of Asp158 that contribute the most to the stabilization of the thiolate-imidazolium ion pair in papain. However, the charge and the hydrogen bonds of Asp158 both contribute to the intrinsic activity of the enzyme.

The baculovirus/insect cell system has been remarkably successful in yielding high levels of synthesis of many proteins which have been difficult to synthesize in other host/vector systems. The system is also capable of secreting heterologous proteins, but with generally low efficiency. We have increased the efficiency of secretion of the system by using signal peptides of insect origin to direct the secretion of a foreign protein. The precursor of the plant cysteine protease papain (propapain) has been used as a report enzyme to compare secretion efficiency. Insect cells infected with a baculovirus recombined with the gene encoding propapain fused to the sequence encoding the honeybee melittin signal peptide secreted over five times more papain precursor than the wild-type prepropapain which used the plant signal peptide. Based on these results, we have assembled pVT-Bac, an Autographa californica nuclear polyhedrosis virus transfer vector that may enhance secretion of other foreign proteins from insect cells. The vector incorporates a number of features: phage f1 ori to facilitate site-directed mutagenesis, the strong polyhedrin promoter upstream from the melittin signal peptide-encoding sequence, and eight unique restriction sites to facilitate fusion of heterologous genes.

The existence of an oxyanion hole in cysteine proteases able to stabilize a transition-state complex in a manner analogous to that found with serine proteases has been the object of controversy for many years. In papain, the side chain of Gln19 forms one of the hydrogen-bond donors in the putative oxyanion hole, and its contribution to transition-state stabilization has been evaluated by site-directed mutagenesis. Mutation of Gln19 to Ala caused a decrease in kcat/KM for hydrolysis of CBZ-Phe-Arg-MCA, which is 7700 M-1 s-1 in the mutant enzyme as compared to 464,000 M-1 s-1 in wild-type papain. With a Gln19Ser variant, the activity is even lower, with a kcat/KM value of 760 M-1 s-1. The 60- and 600-fold decreases in kcat/KM correspond to changes in free energy of catalysis of 2.4 and 3.8 kcal/mol for Gln19Ala and Gln19Ser, respectively. In both cases, the decrease in activity is in large part attributable to a decrease in kcat, while KM values are only slightly affected. These results indicate that the oxyanion hole is operational in the papain-catalyzed hydrolysis of CBZ-Phe-Arg-MCA and constitute the first direct evidence of a mechanistic requirement for oxyanion stabilization in the transition state of reactions catalyzed by cysteine proteases. The equilibrium constants Ki for inhibition of the papain mutants by the aldehyde Ac-Phe-Gly-CHO have also been determined. Contrary to the results with the substrate, mutation at position 19 of papain has a very small effect on binding of the inhibitor.(ABSTRACT TRUNCATED AT 250 WORDS)

A mutant of papain, where an inter-domain hydrogen bond between the side chain hydroxyl group of a serine residue at position 176 and the side chain carbonyl oxygen of a glutamine residue at position 19 has been removed by site-directed mutagenesis, has been produced and characterized kinetically. The mutation of Ser176 to an alanine has only a small effect on the kinetic parameters, the kcat/Km for hydrolysis of CBZ-Phe-Arg-MCA by the Ser176Ala enzyme being of 8.1 x 10(4) /M/s compared with 1.2 x 10(5) /M/s for papain. Serine 176 is therefore not essential for the catalytic functioning of papain, even though this residue is conserved in all cysteine proteases sequenced. The pH-activity profiles were shown to be narrower in the mutant enzyme by up to 1 pH unit at high ionic strength. This result is interpreted to indicate that replacing Ser176 by an alanine destabilizes the thiolate-imidazolium form of the catalytic site Cys25-His159 residues of papain. Possible explanations for that effect are given and the role of a serine residue at position 176 in papain is discussed.

The precursor of the cysteine protease papain has been expressed and secreted as propapain from insect cells infected with a recombinant baculovirus expressing a synthetic gene coding for prepropapain. This 39-kDa secreted propapain zymogen molecule is glycosylated and can be processed in vitro into an enzymatically active authentic papain molecule of 24.5 kDa (Vernet, T., Tessier, D. C., Richardson, C., Laliberte, F., Khouri, H. E., Bell, A. W., Storer, A. C., and Thomas, D. Y. (1990) J. Biol. Chem. 265, 16661-16666). Recombinant propapain was stabilized with Hg2+ and purified to homogeneity using affinity chromatography, gel filtration, and ion-exchange chromatographic procedures. The maximum rate of processing in vitro was achieved at approximately pH 4.0, at a temperature of 65-degrees-C and under reducing conditions. Precursor processing is inhibited by a variety of reversible and irreversible cysteine protease inhibitors but not by specific inhibitors of serine, metallo or acid proteases. Replacement by site-directed mutagenesis of the active site cysteine with a serine at position 25 also prevents processing. The inhibitor I-125-N-(2S, 3S)-3-trans-hydroxycarbonyloxiran-2-carbonyl-L-tyrosine benzyl ester covalently labeled the wild type papain precursor, but not the C25S mutant, indicating that the active site is accessible to the inhibitor and is in a native conformation within the precursor. Based on biochemical and kinetic analyses of the activation and processing of propapain we have shown that the papain precursor is capable of autoproteolytic cleavage (intramolecular). Once free papain is released processing can then occur in trans (intermolecular).

1. Three synthetic substrates of cathepsin B (EC 3.4.22.1) with various amino acid residues at the P2 position (Cbz-Phe-Arg-NH-Mec, Cbz-Arg-Arg-NH-Mec and Cbz-Cit-Arg-NH-Mec, where Cbz represents benzyloxycarbonyl and NH-Mec represents 4-methylcoumarin-7-ylamide) were used to investigate the pH-dependency of cathepsin B-catalysed hydrolyses and to obtain information on the nature of enzyme-substrate interactions. 2. Non-linear-regression analysis of pH-activity profiles for these substrates indicates that at least four ionizable groups on cathepsin B with pKa values of 3.3, 4.55, 5.46 and greater than 7.3 can affect the rate of substrate hydrolysis. 3. Ionization of the residue with a pKa of 5.46 has a strong effect on activity towards the substrate with an arginine in P2 (8.4-fold increase in activity) but has only a moderate effect on the rate of hydrolysis with Cbz-Cit-Arg-NH-Mec (2.3-fold increase in activity) and virtually no effect with Cbz-Phe-Arg-NH-Mec. The kinetic data are consistent with this group being an acid residue with a side chain able to interact with the side chains of an arginine or a citrulline in the P2 position of a substrate. Amino acid sequence alignment and model building with the related enzyme papain (EC 3.4.22.2) suggest that Glu-245 of cathepsin B is a likely candidate. The relative importance of electrostatic and hydrophobic interactions in the S2 subsite of cathepsin B is discussed. 4. For all three substrates, activity appears after ionization of a group with a pKa of 3.3, believed to be the active-site Cys-29 of cathepsin B. The identity of the groups with pKa values of 4.55 and greater than 7.3 remains unknown.

The controversy concerning the various suggested roles for the side chain of Asp158 in the active site of papain has been clarified by using site-directed mutagenesis. Both wild-type papain and an Asp158 Asn variant were produced in a baculovirus-insect cell expression system, purified to homogeneity from the culture, and characterized kinetically. With CBZ-Phe-Arg-MCA as substrate, the kcat/KM and kcat values obtained for the Asp158Asn papain are 20,000 M-1.s-1 and 34 s-1, respectively, as compared with values of 120,000 M-1.s-1 and 51 s-1 obtained for the wild-type papain. In addition, the pH-(kcat/KM) profile for the Asp158Asn enzyme is shifted relative to that for the wild-type enzyme to lower values by approximately 0.3 pH unit. This shows clearly that Asp158 is not, as previously postulated, an essential catalytic residue. In addition, the pH dependency data are interpreted to indicate that, contrary to earlier suggestions, the negatively charged side chain of Asp158 does not significantly stabilize the active-site thiolate-imidazolium ion pair. However, its presence does influence the pKa's associated with ion-pair formation in a manner compatible with electrostatic considerations.

The synthetic gene coding for the precursor of the cysteine protease papain (EC 3.4.22.2) has been expressed using the baculovirus/insect cell system. The prepropapain gene was cloned into the transfer vector IpDC125 behind the polyhedrin promoter. The recombinant construct was then incorporated by homologous recombination into the Autographa californiaca nuclear polyhedrosis virus genome. The host Spodoptera frugiperda Sf9 cells infected with the recombinant baculovirus secrete an enzymatically inactive N-glycosylated papain precursor. This zymogen could be activated in vitro to yield about 400 nmol of active papain per liter of culture. The recombinant active mature papain was enzymatically indistinguishable from natural papain but the precursor was not processed to the same amino acid residue. The insect cells also accumulated prepropapain and glycosylated propapain intracellularly. This accumulation was an indication that there are rate-limiting steps in the secretion of proteins from insect cells in this expression system. Characterization of mutants of the precursor has shown that entry into the secretory pathway and addition of carbohydrate are prerequisite conditions for the production and secretion of functional propapain.

(3-si,4-re)-2,5-Dihydroxyacetanilide epoxidase (DHAE I), a key enzyme in the biosynthesis of the epoxysemiquinone antibiotic LL-C10037a by Streptomyces LL-C10037