Dry powders containing a live-attenuated Newcastle disease vaccine (LZ58 strain) and intended for mass vaccination of poultry were prepared by spray drying using mannitol in combination with trehalose or inositol, polyvinylpyrrolidone (PVP) and/or bovine serum albumin (BSA) as stabilizers. These powders were evaluated for vaccine stabilizing capacity during production and storage (at 6 degrees C and 25 degrees C), moisture content, hygroscopicity and dry powder dispersibility. A mixture design, varying the ratio of mannitol, inositol and BSA, was used to select the stabilizer combination which resulted in the desired powder properties (i.e. good vaccine stability during production and storage, low moisture content and hygroscopicity and good dry dispersibility). Inositol-containing powders had the same vaccine stabilizing capacity as trehalose powders, but were less hygroscopic. Incorporation of BSA enhanced the vaccine stability in the powders compared to PVP-containing formulations. However, increasing the BSA concentration increased the hygroscopicity and reduced the dry dispersibility of the powder. No valid mathematical model could be calculated for vaccine stability during production or storage, but the individual experiments indicated that a formulation combining mannitol, inositol and BSA in a ratio of 73.3:13.3:13.3 (wt/wt) resulted in the lowest vaccine titre loss during production (1.6-2.0 log(10) 50% egg infectious dose (EID50) and storage at 6 degrees C (max. 0.8 log(10) EID50 after 6 months) in combination with a low moisture content (1.1-1.4%), low hygroscopicity (1.9-2.1% water uptake at 60% relative humidity) and good dry dispersibility properties. (C) 2011 Elsevier B.V. All rights reserved.

Thirteen thirty-week-old layers (Lohman Silver) that showed lameness were necropsied. Sera were collected and bacterial isolation was performed. Gross examination revealed amyloid deposits in the joints. The lesion was limitedly present only in knee joints. Enterococcus faecalis was the predominant microorganism isolated. Tissues from joints, liver, spleen, and kidney were positive with anti-chicken AA antisera using EnvisionTM + Peroxidase. SAA levels were generally increased in amyloidotic sera using direct ELISA but relatively low compared to acute phase sera. Moreover, Western Blot analysis revealed a low signal of SAA. From these findings, it was concluded that the birds suffered from amyloid arthropathy.

The progression of Escherichia coli lesions was studied in the respiratory tract of 4-week-old commercial broilers. Lesions were induced after a single intratracheal E. coli infection, and after an infection with E. coli preceded 5 days earlier by an oculo-nasal and intratracheal infectious bronchitis virus (IBV) infection of either the virulent M41 strain or the H120 vaccine strain. Trachea, lung and thoracic airsac lesions were examined macroscopically and microscopically. Tissue samples were taken at 3h post-inoculation (hpi), and 1, 2, 4 and 7 days post-inoculation (dpi) with E. coli. The location of both pathogens was assessed by immunohistochemistry. Single E. coli inoculation induced pneumonia and airsacculitis; in case it was preceded by IBV infection, the same macroscopical lesions and also viral tracheitis were found. No clear difference existed between the single and dual infected birds with respect to inflammatory reactions in the lung, which had disappeared within 7 days, except for the presence of more follicles in dual infected birds. IBV antigen was detected in secondary bronchi and airsacs up to 2 dpi and in the trachea up to 4 dpi. E. coli bacteria were found in the tracheal lumen included in purulent material, the parabronchi and airsacs. In lung tissue E. coli antigen was found up to 4 dpi. No clear difference existed between single and dual inoculated birds regarding the presence of E. coli in the lung. In the airsacs, a few bacteria were found from 0.5 hpi up to 4 dpi in E. coli and IBV-E. coli inoculated birds. Although both pathogens were cleared beyond detection at 7 dpi, in IBV-E. coli inoculated birds lesions in the airsac persisted, in contrast to broilers inoculated with E. coli only. In the present study it is shown that 4-week-old broilers are not resistant to intratracheal E. coli inoculation, however, these birds can overcome the induced E. coli infection within a short time span. Moreover, a preceding infection with vaccine or virulent IBV does not seem to impair the clearance of E. coli in the respiratory tract of broilers, but rather induces an exaggerated inflammatory response in the airsacs only, which seems to be the mechanism behind the pattern of airsacculitis in commercial poultry in the field.

Colibacillosis results from infection with avian pathogenic Escherichia coli bacteria. Healthy broilers are resistant to inhaled E. coli, but previous infection with vaccine or virulent strains of Infectious Bronchitis Virus (IBV) predisposes birds for severe colibacillosis. We investigated whether IBV affects recruitment and function of phagocytic cells and examined NO production, phagocytic and bactericidal activity, and kinetics of peripheral blood mononuclear cells (PBMC) and splenocytes. Moreover, we measured cytokine mRNA expression in lung and spleen samples. Broilers were inoculated with IBV H120 vaccine or virulent M41 and challenged 5 days later with E. coli 506. A PBS control and E. coli group without previous virus inoculation were also included. Birds were sacrificed at various time points after inoculation (h/dpi). Inoculation with IBV induced extended and more severe colibacillosis than with E. coli alone. At 4 dpi, the number of KUL-01+ PBMC in all E. coli-inoculated groups was significantly higher than in PBS-inoculated birds, which correlated with lesion scores. From 1 to 4 dpi, NO production by PBMC from all E. coli-inoculated animals was elevated compared to PBS birds. Bactericidal activity of PBMC in IBV-inoculated animals at 7 dpi was lower than in PBS- and E. coli-inoculated birds, but phagocytic capacity and recruitment were not severely impaired. In spleen samples of IBV-infected animals reduced expression of IL-1β, IL-6, IL-8, IL-10, IL-18 and IFN-γ mRNA was found 1 dpi. Our results suggest that enhanced colibacillosis after IBV infection or vaccination is caused at least by altered innate immunity and less by impairment of phagocytic cell function.