Various amounts of one of three different types of cleavable methoxy polyethylene glycol (mPEG)-phospholipids or of a non-cleavable counterpart (mPEG-DSPE) were included into pH-sensitive liposome formulations containing dioleoylphosphatidylethanolamine (DOPE) and cholesterylhemisuccinate (CHEMS) at a 6:4 molar ratio, and the effect on plasma clearance and contents release rates was determined. The cleavable lipopolymers were all based on a distearoylphosphatidyl lipid anchor, which was linked to mPEG via dithiodipropionateaminoethanol (mPEG-DTP-DSPE), dithio-3-hexanol (mPEG-DTH-DSPA), or Gly-Phe-Leu-Gly-aminoethanol (mPEG-GFLG-DSPE) linkers. In contrast to the first-generation thiolytically cleavable lipopolymer, mPEG-DTP-DSPE, the second generation conjugates contained a hindered disulfide or enzymatically cleavable tetrapeptide, respectively, as the points of scission. In the absence of mPEG-lipid, DOPE/CHEMS liposomes had rapid clearance half-lives. As the mol% of mPEG-lipid in the liposomes increased, the rate of clearance of DOPE/CHEMS liposomes in mice decreased. Zeta-potential measurements showed that decreased clearance was correlated with a decrease in the apparent surface charge of the liposomes, which approached neutrality as the content of mPEG-lipids increased to above 15 mol%. At these levels, liposomes containing mPEG-DTP-DSPE were cleared from blood circulation faster than liposomes containing other, less vulnerable lipopolymers. Liposomes with the peptide-linked lipopolymer exhibited the slowest clearance. The presence of either cleavable or non-cleavable mPEG-lipids at concentrations of 5 mol% or higher in the DOPE/CHEMS liposomes inhibited the release of doxorubicin from these liposomes in response to acid pH.

In this paper, we describe the development of micellar formulations for increasing the solubility of lipophilic benzoporphyrins. Using a simple procedure that is readily adaptable for large-scale manufacturing, both A-ring (1) and B-ring isomers (2) of benzoporphyrins could be readily formulated, at concentrations up to 1-2 mg/ml, into small micelles (<20 nm in diameter) of methoxypoly(ethylene glycol) (M(r) 2000) covalently attached to the lipid anchor distearoylphosphatidylethanolamine (mPEG-DSPE). The formulations spontaneously formed upon hydration of a thin film containing mPEG-lipid and photosensitizer and were stable upon storage at 4 degrees C for at least 1 month. Self-association of the B-ring benzoporphyrin isomer in micelles could be efficiently inhibited by either increasing the molar ratio of mPEG(2000)-DSPE to benzoporphyrin or by increasing the pH of the preparation to pH 8.5. The formulation could be freeze-dried and stored indefinitely in the lyophilized form, with restoration of the original properties upon reconstitution. In vivo, the A-ring benzoporphyrin, verteporfin, had higher levels of delivery and greater tumor control in mice than the B-ring derivative when formulated in mPEG(2000)-DSPE micelles and administered intravenously. mPEG(2000)-DSPE micellar formulations also showed tumor control when administered by a single intratumoral injection followed by light irradiation to the tumor within 45-60 min after drug administration. PEG-containing micellar formulations may be a promising delivery system for benzoporphyrin monoesters for clinical applications.