The aim of this study was to demonstrate the reliability of the protein determination methods used in the process of recombinant human insulin development before its scale up.The total protein content was measured by Bradford, molar extinction coefficient, and dry weight methods.The standards were analyzed using Mono-Q, Aquapore RP300, and Kromasil columns to calculate the concentrations of the proteins using the theoretical extinction coefficient and peak area.The following highly purified standards were used: batches B4-258 and QS009-010 of the sulfonated fusion protein; batches B4-267, B4-268, RALF-018, HGUT-042, HGUT-043, and HGUT-045 of the renatured fusion protein; the United States Pharmacopeia reference; and batch B4-253 of bulk insulin crystals.The results were analyzed using ANOVA or Student's t-test at 95% significance.The Bradford method showed up to 60% variation for all evaluated standards, while the remaining two methods were consistent with each other.The chromatographic parameters were used to validate the analytical methods, and all results met the current guidelines of Brazilian regulatory agencies.The use of quality parameters and the statistical evaluation of the data demonstrated that analytical methods used in the in-process control are suitable for the intended purpose, which certifies the reliability of the generated data.

To date, there is no vaccine available against human leishmaniasis. Although some vaccination protocols can induce immunity in murine models, they fail to induce protection in humans. The reasons for that remain unclear. The aim of the present study was to characterize the changes in the pattern of the immune response during subcutaneous vaccination with Leishvacin® in mice. We also investigated whether IFN-γ and nitric oxide synthase are indispensable for the protection elicited by the vaccine. C57BL/6 WT vaccinated mice showed smaller lesions and fewer numbers of parasites in footpads until 8weeks post-infection. Up to this time, they produced higher levels of IFN-γ, IL-2, IL-4, IL-17A and IL-10 and higher specific antibody response than control non-vaccinated mice. Moreover, we showed that IFN-γ, most likely by induction of iNOS expression, is essential for immunity. However, after 12weeks of infection, we observed loss of difference in lesion size and parasite burden between the groups. Loss of resistance was associated with the disappearance of differences in cytokine patterns between vaccinated and control mice, but not of antibody response, which remained different until a later time of infection. The reversal of resistance to L. amazonensis could not be explained by upregulation of regulatory cytokines. Our data point to a subversion of the host immune response by L. amazonensis even when a protective response was previously induced.

Recent innovations in designing purification processes for biopharmaceutical production have enabled initial screening (optimization) of chromatographic conditions for binding to be performed in miniaturized batch format. The present report demonstrates the possibility of using this format to screen for selectivity and illustrates the need for careful adjustment of protocols when highly abundant, tightly-binding impurities are present in the sample. This batch format approach was used to choose a chromatography medium (resin) from a selection of available resins for the purification of recombinant insulin expressed in E. coli and to screen binding and elution conditions. Subsequent optimization was performed in small packed columns using a Design of Experiments (DoE) approach with statistical modeling before scaling up to a small pilot scale experiment. In this study insulin was effectively purified from the more tightly-binding C-peptide, and a reduction in insulin variants was also noted using the optimized conditions.

Protozoa of the genus Leishmania are intracellular parasites of macrophages and may cause diverse clinical forms of leishmaniasis, including cutaneous, diffuse cutaneous, mucocutaneous and visceral leishmaniasis. Infection with L. major in mice indicates that a protective immune response is achieved when Th1 cells are developed. Thus, adoptive or vaccine-induced protection against leishmaniasis is largely dependent on cell-mediated immunity and IFN-gamma production. Induction of a Th1 response is dependent on the presence of IL-12 whilst lymphocytes are activated. This study was aimed at evaluating the role of IL-12 during infection with L. amazonensis and after vaccination with Leishvacin (killed Leishmania amazonensis promastigotes), since the role of this cytokine in vaccine-induced immunity with this preparation in experimental models or in humans is not yet elucidated. Hence, C57BL/6 interleukin-12-deficient mice (IL-12p40(-/-)) and wild-type controls (wt) were infected with L. amazonensis and the course of infection, parasite burden and cytokine production were compared. IL-12p40(-/-) mice were more susceptible to L. amazonensis than wt: lesions and parasite burden were larger in IL-12p40(-/-) when compared to wt. Interestingly, IL-4 was not produced in the absence of IL-12 in response to infection with L. amazonensis. To evaluate the role of IL-12 in the vaccine-induced immunity against L. amazonensis infection, IL-12p40(-/-) wt mice were vaccinated in the base of the tail and subsequently challenged with L. amazonensis in the footpads. Surprisingly, vaccinated IL-12p40(-/-) mice developed smaller lesions and had fewer parasites in footpads than non-vaccinated controls. Lymph node and spleen cells from vaccinated IL-12p40(-/-) mice did not produce high levels of IFN-gamma in response do in vitro stimulus with antigen. Hence, partial protection against infection with L. amazonensis could be obtained in the absence of functional IL-12 and a typical Th1 response.

Proinsulin C-peptide has been recently described as an endogenous peptide hormone, responsible for important physiological functions others than its role in proinsulin processing. Accumulating evidences that C-peptide exerts beneficial effects in the treatment of long term complications of patients with type 1 diabetes mellitus indicate that this molecule may be administered together with insulin in future therapies. Despite its clear pharmacological interest, the secondary and three-dimensional (3D) structures of human C-peptide are still points of controversy. In the present work we report molecular dynamics (MD) simulations of human, rat I and rat II C-peptides. A common experimental strategy applied to all peptides consisted of homology building followed by multinanosecond MD simulations in vacuum and water. Circular dichroism (CD) experiments of each peptide in the absence and presence of 2,2,2-trifluoroethanol (TFE) were performed to support validation of the theoretical models. A multiple sequence alignment of 23 known mammalian C-peptides was constructed to identify significant conserved sites that would be important for the maintenance of secondary and tertiary structures. The analysis of the molecular dynamics trajectories for the human, rat I and rat II molecules have shown quite different general behavior, being the human C-peptide more flexible than the two others. Human and rat C-peptides exhibit very stable turn-like structures at the middle and C-terminal regions, which have been described as potential active sites of C-peptides. Human C-peptide also presented a short alpha-helix throughout the MD, which was not found in the rat molecules. CD data is in very good agreement with the MD results and both methods were able to identify a greater structural stability and potential in rat C-peptides when compared to the human C-peptide. The simulation results are discussed and validated in the light of multiple sequence alignment, recent experimental data from the literature and our own CD experiments.

The C-peptide of proinsulin is important for the biosynthesis of insulin, but has been considered for a long time to be biologically inert. Recent studies in diabetic patients have stimulated a new debate about its possible regulatory role, suggesting that it is a hormonally active peptide. We describe structural studies of the C-peptide using 2D NMR spectroscopy. In aqueous solution, the NOE patterns and chemical shifts indicate that the ensemble is a nonrandom structure and contains substructures with defined local conformations. These are more clearly visible in 50% H2O/50% 2,2,2-trifluoroethanol. The N-terminal region (residues 2-5) forms a type I beta-turn, whereas the C-terminal region (residues 27-31) presents the most well-defined structure of the whole molecule including a type III'beta-turn. The C-terminal pentapeptide (EGSLQ) has been suggested to be responsible for chiral interactions with an as yet uncharacterized, probably a G-protein-coupled, receptor. The three central regions of the molecule (residues 9-12, 15-18 and 22-25) show tendencies to form beta-bends. We propose that the structure described here for the C-terminal pentapeptide is consistent with the previously postulated CA knuckle, believed to represent the active site of the C-peptide of human proinsulin.

The peculiarities of molecular structures and the influence of reaction conditions on the folding efficiency of fusion proteins—biotechnological precursors of human insulin, expressed in Escherichia coli as inclusion bodies have been investigated. The fusion proteins contained proinsulin sequence with various leader peptides connected by an Arg residue to the insulin B-chain. The kind and the size of leader peptide do not have essential influence on folding efficiency. However, the efficiency of protein folding depends on the location of the (His)6 site, which is used for metal-chelating affinity chromatography. In our study the protein folding depends on the reaction medium composition (including additives), the presence of accompanied cell components, pH, temperature, concentrations of protein, and redox agents. A negative influence of nucleic acid and heavy metal ions on folding has been found. S-sulfonated fusion protein has proinsulin-like secondary structure (by CD-spectroscopy data) that is the key point for 95% efficient folding proceeding. Folded fusion proteins are transformed into insulin by enzymatic cleavage.

Various methods have been investigated for the isolation and purification of fusion proteins of precursors of human insulin in the form of S-sulfonates, from the biomass of transformed Escherichia coli cells. Fusion proteins were prepared with different sizes and structures of the leader peptide and the poly-His position (inserted for purification by metal chelate affinity chromatography). The fusion proteins contained an IgG-binding B domain of protein A from Staphylococcus aureus at the N-terminus and an Arg residue between the leader peptide of the molecule and the proinsulin sequence, for trypsin cleavage of the leader peptide. Six residues of Cys in proinsulin allow the chemical modification of the protein as a (Cys-S-SO(-)(3))(6) derivative (S-sulfonate), which increases its polyelectrolytic properties and improves the efficiency of its isolation. Various methods of oxidative sulfitolysis were compared with catalysis by sodium tetrathionate or cystine and Cu2+ or Ni2+ ions. An optimum scheme for the isolation and purification of S-sulfonated fusion proteins was developed by the combination of metal-chelating affinity and ion-exchange chromatography. Highly purified (95%) S-sulfonated fusion protein was recovered which was 85% of the fusion protein contained in the biomass of E. coli cells. Folding of fusion protein S-sulfonate occurred with high yield (up to 90-95%). We found that the fusion protein-S-sulfonate has proinsulin-like secondary structure. This structure causes highly efficient fusion protein folding.

Various methods have been investigated for the isolation and purification of fusion proteins of precursors of human insulin in the form of S-sulfonates, from the biomass of transformed Escherichia coli cells. Fusion proteins were prepared with different sizes and structures of the leader peptide and the poly-His position (inserted for purification by metal chelate affinity chromatography). The fusion proteins contained an IgG-binding B domain of protein A from Staphylococcus aureus at the N-terminus and an Arg residue between the leader peptide of the molecule and the proinsulin sequence, for trypsin cleavage of the leader peptide. Six residues of Cys in proinsulin allow the chemical modification of the protein as a (Cys-S-SO(-)(3))(6) derivative (S-sulfonate), which increases its polyelectrolytic properties and improves the efficiency of its isolation. Various methods of oxidative sulfitolysis were compared with catalysis by sodium tetrathionate or cystine and Cu2+ or Ni2+ ions. An optimum scheme for the isolation and purification of S-sulfonated fusion proteins was developed by the combination of metal-chelating affinity and ion-exchange chromatography. Highly purified (95%) S-sulfonated fusion protein was recovered which was 85% of the fusion protein contained in the biomass of E. coli cells. Folding of fusion protein S-sulfonate occurred with high yield (up to 90-95%). We found that the fusion protein-S-sulfonate has proinsulin-like secondary structure. This structure causes highly efficient fusion protein folding.

A proinsulin analog constructed by site-directed mutagenesis was expressed as a fusion protein that formed inclusion bodies inside the cells. It was purified from the isolated inclusion bodies and proinsulin was obtained by trifluoro-acetic acid, dimethyl sulfoxide and hydrochloric acid cleavage. The released proinsulin analog was confirmed by its molecular weight as determined by SDS-PAGE.