Octamethylcyclotetrasiloxane (D4) is a low-molecular-weight cyclic siloxane used primarily in the synthesis of silicone polymers. The objective of the present study was to evaluate the subchronic toxicity of D4 following a 3-month nose-only inhalation exposure. Male and female Fischer 344 rats (20/sex/group) were exposed 6 h/day, 5 days/week for 3 months to vapor concentrations of 0, 35, 122, 488, and 898 ppm D4. Also, an additional 10 per sex in the control and high-exposure groups were allowed a 4-week recovery period to observe reversibility, persistence, or delayed occurrence of any potential adverse effects. Body weights and food consumption were monitored at least twice weekly over the course of exposures. Approximately 18 hours preceding euthanasia, animals were transferred into metabolism cages for urine collection, and were fasted. At necropsy, rats were anesthetized with pentobarbital and euthanized by exsanguination. Blood was collected for hematological and clinical biochemical analyses. Selected organ weights were measured and a complete set of tissues was taken for histopathological examination. A concentration-dependent increase in absolute and relative liver weight (488 to 898 ppm) and a significant decrease in ovarian weight (898 ppm) were observed in female rats. Exposure to D4 via nose-only inhalation (35 to 898 ppm) produced minor alterations in hematological and serum chemistry parameters that were considered either incidental and of little toxicological significance (hematology) or suggestive of metabolic adaptation/alteration (serum chemistry) in response to exposure-related hepatomegaly. There were no histopathological findings noted in the liver. Histopathological evidence indicated the primary target organs following D4 inhalation exposure to be components of the female reproductive tract. Reversible histopathological changes were observed in the ovary (hypoactivity) and vagina (mucification) of female rats in the high-dose group only (898 ppm). Although an increase in the incidence and severity of both macrophage accumulation, interstitial inflammation, and eosinophil infiltration was observed in the lungs of male and female rats exposed to D4, the toxicological significance is uncertain as other inhalation studies at similar concentrations failed to show these effects. In summary, nose-only inhalation of a high concentration of D4 resulted in reversible histopathological changes in the female rat reproductive tract. Lower concentrations did not elicit these same effects.

Octamethylcyclotetrasiloxane, D-4, isa low viscosity, silicone fluid consisting of four dimethyl-siloxy units ((CH3)(2)SiO)(4) in a cyclic structure. It is primarily used as a building block in the industrial synthesis of long chain silicone polymers. The combination of D-4 with decamethylcyclopentasiloxane (D-5) is commonly referred to as cyclomethicone which has a wide range of applications as a formulation aid in personal care products. To extend the existing database regarding the biological activities of D-4, a 28 day whole body vapor inhalation study was conducted using Fischer 344 rats at 0 (room air), 7, 20, 60, 180 and 540 ppm for 6 hours/day, 5 days/week. Parameters measured included body weights, organ weights, gross pathology, histopathology, serum chemistries, and urinalysis. In addition to these standard toxicological endpoints, the ability of D-4 exposed animals to mount an IgM antibody response was evaluated by a splenic antibody forming cell (AFC) assay and a serum enzyme-linked immunosorbant assay (ELISA). The results of this 28-day inhalation study indicate that D-4 exposure caused no adverse effects on body weight, food consumption, or urinalysis parameters. In addition, there were no exposure related histopathological alterations at any site for any exposure group. A statistically significant increase in liver weight and the liver to body weight ratio was observed in both male (180-540 ppm) and female (20-540 ppm) rats, which was not observed in the 14-day recovery group animals. There were no other significant organ weight changes. Although statistically significant changes were observed in several hematological and serum chemistry parameters in both the terminal and 14-day recovery animals, the changes were marginal and within the normal range of values for the rat. Under these experimental conditions, there were no alterations noted in immune system function at any of the D-4 exposure levels.

Three drugs that affect the neuroendocrine system (amphetamine, methylphenidate, and codeine) caused decreases in body weights and in the incidence of spontaneously occurring mammary gland neoplasms in the female F344/N rat in 2-year carcinogenicity studies. Using a mathematical model that relates body weight changes to the incidence of mammary gland neoplasms, we find that the decrease in mammary gland tumors seen in female rats cannot be fully explained by body weight decreases relative to control animals. Further, the observed decreases in body weight in treated female rats were not a function of differences in feed consumption between treated and control groups. These pharmaceuticals are thought to affect the biologic system through interaction with membrane receptors. This interaction and/or subsequent cell signaling events may play a role in the observed decrease in spontaneously occurring mammary gland neoplasms in the female rat treated with amphetamine, methylphenidate, or codeine.