This study was conducted to determine the stage of maturity at which the dry matter (DM) yield and nutritive value of velvet bean (Mucuna pruriens) is optimized. Mucuna was harvested at 77, 110 and 123 days after planting (DAP) from quadruplicate 5m×1m plots within each of 6 blocks. At each DAP, DM yield, chemical composition, botanical composition, in vitro rumen fluid-pepsin DM digestibility (IVDMD) and concentrations of total polyphenols, l-dopa and tannins were determined on the whole plant and botanical fractions. Whole-plant Mucuna DM yield increased (P<0.01) linearly with maturity; proportions of leaves and stems decreased linearly (P<0.01), whereas proportion of pods increased (P<0.01). Concentrations of neutral-detergent fiber (aNDF) in whole plant, leaf, and stem increased (P<0.05), or tended (P<0.10) to increase linearly with maturity, as did the acid-detergent fiber concentration of leaves and stems. Maturity decreased (P<0.05) ether extract concentrations of leaves linearly, and stems quadratically, but increased (P<0.05) whole-plant and pod starch concentrations. Pods contained relatively high concentrations of lysine, histidine, phenylalanine, aspartate, glutamate, leucine, isoleucine, and valine, but low concentrations of methionine and cystine. The essential amino acid index did not vary with maturity. Most minerals in Mucuna are concentrated in the leaves and the whole plant contains sufficient Ca, P, K, Mg, Fe, Cu, Na, Mo, Mn, and Zn for growing sheep, although their bioavailability of these minerals is unknown. Total polyphenol concentration quadratically (P<0.01) increased with maturity in the whole plant, tended to increase (P<0.10) in pods, linearly (P<0.01) decreased in stems and fluctuated in leaves. Maturity quadratically increased l-dopa concentration of the whole plant (P<0.05) and stems (P<0.01), but did not affect those of leaves and pods. Maturity quadratically increased (P<0.05) total tannin concentration in the whole plant, but decreased (P<0.10) that of pods. The l-dopa was concentrated in the seeds and pods of mature (110–123DAP) plants, but tannins were concentrated in leaves and stems. Whole-plant IVDMD was not affected by maturity, but digestible DM yield linearly (P<0.01) increased with increasing DM yield. There was a 2-week harvest window (110–123DAP) during which whole-plant crude protein and IVDMD remained unchanged. Nevertheless, harvesting at 123DAP gave the best combination of biomass yield and nutritive value.

Mucuna pruriens seeds have relatively high crude protein (CP) concentrations, but little is known about their potential to replace commonly used CP supplements in ruminant rations. The aim of this experiment was to determine effects of replacing soybean meal (SB) with Mucuna on the performance of lambs. Forty Rambouillet lambs (33.2±5.73kg) fed a basal diet of maize grain, cottonseed hulls and urea were randomly assigned to one of four supplements formulated by substituting 0 (SB), 330 (Lo), 670 (Med) or 1000g/kg (Hi) of soybean meal with rolled Mucuna seeds. Lambs were housed individually in metabolic crates and allowed ad libitum access to isocaloric (metabolizable energy=11.7MJ/kg dry matter, DM) and isonitrogenous (CP=146g/kg, DM) diets for 14d of adaptation and 7d of total fecal collection. Fecal egg counts and coccidian oocyst scores were determined on d 14. Dry matter intake (1.7kg/d versus 1.5kg/d; P<0.05), CP digestibility (774g/kg versus 714g/kg DM; P<0.05) and N retention (28.0g/d versus 20.4g/d; P<0.01) were higher and amylase-pretreated neutral detergent fiber digestibility (617g/kg versus 686g/kg DM) was lower (P<0.05) in sheep fed SB versus Mucuna diets. However, supplementary protein source did not affect rumen pH, blood urea N or glucose concentration, or fecal egg counts. Increasing the level of Mucuna supplementation increased (P<0.05) level and efficiency of microbial protein synthesis, ruminal fluid acidity, total volatile fatty acid concentration, decreased (P<0.05) coccidian oocyst scores, and tended (P<0.10) to increase N retention. Therefore, SB is a better supplement than Mucuna to support performance of lambs. Nevertheless, Mucuna seeds are a promising CP supplement for situations where cost or availability precludes use of SB in ruminant rations.