Asbestos was largely used in Brazil. It is a mineral that induces pleural and pulmonary fibrosis, and it is a potent carcinogen. Our objective was to develop recommendations for the performance of adequate imaging tests for screening asbestos-related diseases. We searched peer-reviewed publications, national and international technical documents, and specialists' opinions on the theme. Based on that, the major recommendations are: Individuals exposed to asbestos at the workplace for = 1 year or those with a history of environmental exposure for at least 5 years, all of those with a latency period > 20 years from the date of initial exposure, should initially undego HRCT o f the chest for investigation. Individuals with pleural disease and/or asbestosis should be considered for regular lung cancer monitoring. Risk calculators should be adopted for lung cancer screening, with a risk estimate of 1.5%.

ObjectiveTo evaluate silicosis diagnosed through CT, with integration of clinical-occupational data, in silica-exposed workers presenting chest X-rays within International Labor Organization (ILO) category 0.MethodsCross-sectional study with 339 former gold miners, with comparable exposures and X-rays classified as ILO subcategory 0/0 (n=285) and 0/1 (n=54) were submitted to volume-based CT. The findings were classified according to the International Classification of HRCT CT for Occupational and Environmental Respiratory Diseases.ResultsA profusion degree of round opacities (RO)>1 was found in 22.4% (76/339) of the CT exams. After integrating the CT findings with clinical and occupational data, silicosis was diagnosed as follows: 43/285 (15.1%) and 14/54 (25.9%) in workers whose X-rays had been classified as 0/0 and 0/1, respectively. There was an upward trend towards longer exposures, reaching 38.9% when working more than 10 years underground and classified as 0/1 (p=0019). Those with presence of RO whose final diagnosis was not silicosis were mainly cases of tuberculosis or ‘indeterminate nodules’. Emphysema was found in 65/339 (19.1%), only 5 being detected in the X-ray.ConclusionVolume-based CT proved to be useful in the investigation of silicosis among individuals with a relevant exposure to silica, capturing diagnoses that had not been identified on X-rays. A response gradient of silicosis was showed by CT even in this population with ILO category 0 radiographs. It can be indicated based on quantitative and/or qualitative criteria of occupational exposure, especially considering the possibilities of low CT dosage.

Background Uncontrolled occupational exposure to silica is still frequent in Brazil, with several recent records in the state of Minas Gerais. However, few national studies have addressed silica-related diseases other than silicosis. Aims To describe the occurrence of the main non-malignant silica-related diseases: silicosis, tuberculosis (TB), chronic obstructive pulmonary disease (COPD), and autoimmune diseases in a specialized outpatient clinic. Methods Case series study of 1525 patients exposed to silica, seen between 1984 and 2021, with descriptive findings of clinical and occupational data from the first medical evaluation. Results Medians of age and exposure time were 47 and 15 years, respectively, and 97% of patients were male. The prevalence of silicosis was 44%, of which 27% had large opacities. The main occupational sectors were underground gold mining (28%), precious and semi-precious stone work (20%), and artisanal mining (9%). Spirometries were abnormal in 55%, with obstructive disorder being the most common finding. COPD (25%), active TB or sequelae (12%), and connective tissue diseases (6%) were diagnosed in patients with and without silicosis. Conclusions The percentage of silicosis appears to be alarming, even considering the biases of selective referrals. The patients were relatively young and already had a functional impact, caused not only by silicosis but by one or more silica-related diseases. COPD, TB, and connective tissue diseases proved to be frequent, leading to the need for specifics protocols to investigate them in individuals exposed to silica. By adopting strategies to combat silicosis, the prevention of other silica-related diseases is concomitantly promoted.

Resumo Introdução A tuberculose, caracterizada pela Organização Mundial de Saúde (OMS) como emergência sanitária mundial, é uma doença de impacto global. Objetivo Realizar série histórica de casos de tuberculose em um período de 17 anos em Ouro Preto, Minas Gerais, considerando a histórica relação da doença com a mineração. Método Dados foram obtidos em sistema próprio de registros do município, por busca ativa em prontuários médicos e comparados à quantidade de casos notificados no Sistema de Informação de Agravos de Notificação (SINAN). Para análises de tendência, foram utilizados modelos de regressão polinomial para séries históricas. Resultados Idade média dos casos foi 40,3 ± 16,4 anos. Homens apresentaram 2,23 vezes mais casos e chance 2,07 vezes maior para desfechos negativos. A forma mais observada foi pulmonar (84%), e sorologia para HIV foi realizada em apenas 16,3% dos registros. Principal desfecho observado foi cura (70%), e desfechos negativos totalizaram 20,2% dos registros. Taxa de incidência média foi 29,76 e 16,23 casos/100 mil habitantes na área municipal e distrital, respectivamente. Conclusão Apesar da relação histórica entre mineração e tuberculose no município, observa-se que este ainda apresenta preocupantes vulnerabilidades em relação à vigilância da doença. Análise de série temporal sugeriu declínio na proporção de casos curados entre 2009 e 2015.

BACKGROUND Silicosis is the most prevalent pneumoconiosis in Brazil. We aimed to estimate mortality rates and temporal trends for silicosis, and to identify areas of highest mortality. METHODS Records of silicosis as the underlying (1980-2017) or contributory (2000-2017) cause of death in adults aged 20 years and older were retrieved from the Brazilian Mortality Database. Age-standardized mortality rates (ASMR) were calculated. The annual trend in ASMR was analyzed by joinpoint regression. Mortality rates per 100,000 person-years were calculated for each municipality. We analyzed temporal trends in municipalities where similar activities with exposure to silica were performed. RESULTS There were 3164 death records (96.6% men) distributed over 14% of the municipalities. Mean age of death was 59.2 (SD 15.1) and mean ASMR was 0.085/100,000 (confidence interval 0.080-0.091). Joinpoint regression showed a significant increase in ASMR from 1980 to 2006 and a significant decrease after 2006 driven by a decline in deaths of individuals younger than 70 years. The highest mortality rate was 21.83/100,000 person-years, in a municipality with small mining operations for gems. Gold mining municipalities showed the highest composite death rate, 4.0/100,000 person-years. Tuberculosis was the main cause of death when silicosis was a contributing cause. CONCLUSIONS In contrast with developed countries, silicosis mortality in Brazil increased to 2006 and subsequently started to drop, mostly from a plateau or decrease in deaths occurring in municipalities which regulated economic activities. However, this decrease did not occur in the older age group nor in the unregulated sector, the latter being the main challenge for exposure control and surveillance.

Hypersensitivity pneumonia is an immune-mediated inflammation of the lung parenchyma that occurs in previously susceptible individuals, after inhalation of antigens, usually organic. In recent years, various chemical agents have been described as inducers of hypersensitivity pneumonia, including exposure to high concentrations of pesticides. The objective of the present case report was to describe a possible association of hypersensitivity pneumonia with pesticide chronic inhalation and to draw attention to the importance of early diagnosis. The patient was 72-year-old man who worked for over 30 years as a health agent fumigating pesticides in rural and urban areas. He had progressive dyspnea and cough for the past 3 years. Chest tomography demonstrated parenchymal bands, honeycombing, and diffuse air trapping. Spirometry showed a severe restrictive pattern. Surgical lung biopsy was indicated, which confirmed the diagnosis of hypersensitivity pneumonia. Due to the wide use of pesticides in Brazil, the knowledge of their association with hypersensitivity pneumonia is of great importance in warning the teams involved in health care and surveillance of these workers, providing earlier diagnoses, with better prognosis. On the contrary, late diagnoses, such as that of the case reported, have important health impacts. As a priority, preventive measures must be taken to protect exposed individuals.

BACKGROUND:Identification of biomarkers associated with the diagnosis and prognosis of silicosis would be highly advantageous in the clinical setting. The aim of this study is to evaluate inflammatory and oxidative stress biomarkers in subjects exposed to silica.METHODS:A cross-sectional study of crystal craftsmen currently (n = 34) or formerly (n = 35) exposed and a group of nonexposed subjects (n = 12) was performed. Personal respirable dust samples were collected. Plasma inflammatory mediators (bone morphogenetic protein- BMP2 and chemokines CXCL16, and CCL5), oxidative stress enzymes (thiobarbituric acid reactive substances [TBARs] and superoxide dismutase [SOD]), and nitrite (NO2- ) were analyzed in parallel with nitric oxide in exhaled breath (FeNO).RESULTS:Being currently or formerly exposed to silica was related to increased levels of CXCL16 and TBARs. Currently, exposed subjects showed decreased levels of SOD. Thirty-seven craftsmen with silicosis (26 formerly and 11 currently exposed) showed higher levels of CXCL16, which was positively associated with the radiological severity of silicosis. Compared with the nonexposed, subjects with silicosis had higher levels of TBARs and those with complicated silicosis had lower levels of SOD. In multivariate analysis, higher levels of CXCL16 were associated with exposure status and radiological severity of silicosis. Smoking was not a confounder. FeNO did not distinguish between the exposure status and the presence of silicosis.CONCLUSION:CXCL16 emerged as a potential biomarker that could distinguish both silica exposure and silicosis. TBARs were elevated in exposed individuals. However, their clinical applications demand further investigation in follow-up studies of representative samples.

Exposure to environmental and occupational particulate matter (PM) induces health effects on the cardio-pulmonary system. In addition, associations between exposure to PM and metabolic syndromes like diabetes mellitus or obesity are now emerging in the literature. Collection of exhaled breath condensate (EBC) is an appealing non-invasive technique to sample pulmonary fluids. This hypothesis-generating study aims to (1) validate an ion chromatography method allowing the robust determination of different metabolism-related molecules (lactate, formate, acetate, propionate, butyrate, pyruvate, nitrite, nitrate) in EBC; (2) apply this method to EBC samples collected from workers exposed to quartz (a known inflammatory particle), to soapstone (a less inflammatory particle than quartz), as well as to controls. A multi-compound standard solution was used to determine the linearity range, detection limit, repeatability and bias from spiked EBC. The biological samples were injected without further treatment into an ion chromatograph with a conductivity detector. RTube ® were used for field collection of EBC from 11 controls, 55 workers exposed to soapstone and 12 volunteers exposed to quartz dust. The analytical method used proved to be adequate for quantifying eight anions in EBC samples. Its sub-micromolar detection limits and repeatability, combined with a very simple sample preparation, allowed an easy and fast quantification of different glycolysis or nitrosative stress metabolites. Using multivariate discriminant analysis to maximize differences between groups, we observed a different pattern of anions with a higher formate/acetate ratio in the EBC samples for quartz exposed workers compared to the two other groups. We hypothesize that a modification of the metabolic signature could be induced by exposure to inflammatory particles like quartz and might be observed in the EBC via a change in the formate/acetate ratio.

Resumo Introdução: Minas Gerais é o estado brasileiro com maior registro de casos de silicose, sendo grande parte proveniente de casuísticas acumuladas das minerações de ouro. Objetivos: descrever e analisar temporalmente a ocorrência de silicose na mineração de ouro identificando fatores ocupacionais relacionados. Métodos: estudo transversal com 1.020 ex-mineiros da região de Nova Lima/MG, avaliados entre 1995 e 2011. Resultados: o diagnóstico de silicose foi confirmado em 19,7% dos avaliados. Nenhum caso da doença foi identificado em indivíduos que trabalharam apenas na superfície. A prevalência no grupo que trabalhou até 5 anos no subterrâneo foi de 3,8% e no grupo com mais de 20 anos de trabalho nesse local foi de 44,2%. Os admitidos para trabalho subterrâneo até 1950 apresentaram prevalência de 57,9%. Entre os admitidos após 1990, não houve registro de casos. Conclusão: verificou-se uma queda expressiva na ocorrência de silicose no período analisado. Uma vez que a doença é sabidamente dose-dependente, é esperado que a diminuição dos níveis de exposição, obtido pelas melhorias dos ambientes ocupacionais, tenha refletido nestes resultados. É fundamental que tais medidas continuem a ser adotadas na mineração e em outros ramos de atividade visando reduzir a ocorrência da doença.

A particle exposure assessment based on the dose deposited in the lungs would be the gold standard for the evaluation of any resulting health effects. Measuring particles in exhaled breath condensate (EBC)-a matrix containing water and airway lining fluid-could help to evaluate particle retention in the lungs. This study aimed to (1) validate a nanoparticle tracking analysis (NTA) method for determining the particle number concentration and their hydrodynamic size distribution in EBC, and (2) apply this method to EBC collected from workers exposed to soapstone (n = 55) or quartz dust (n = 12) and controls (n = 11). A standard latex bead solution was used to determine the linear range, limit of detection (LOD), repeatability (coefficient of variation, CV), and bias in spiked EBC. An LM10 NanoSight instrument with NTA version 3.1 software was used for measurement. RTubes® were used for field collection of EBC. The repeatability obtained for a D50 size distribution in EBC showed less than 8% variability, with a bias <7%. The particle concentration was linear in the range ≤2.5 × 108 particles ml-1 with a LOD of 4 × 106 particles ml-1. A recovery of 117 ± 20% at 6.2 × 107 particles ml-1 was obtained with a CV <10% and a bias <20%. EBC from workers exposed to quartz, who experienced the largest exposure to silica particles, consistently exhibited a statistically significant (p < 0.01) higher concentration of particles in their EBC, with a size distribution shift towards larger values than the other groups. Results showed that the NTA technique performed well for characterizing the size distribution and concentrations of particles in EBC. The technique needs to be corroborated with a larger population of workers.

ABSTRACT Objective: To analyze mortality from idiopathic pulmonary fibrosis (IPF) in Brazil over the period 1979-2014. Methods: Microdata were extracted from the Brazilian National Ministry of Health Mortality Database. Only deaths for which the underlying cause was coded as International Classification of Diseases version 9 (ICD-9) 515 or 516.3 (until 1995) or as ICD version 10 (ICD-10) J84.1 (from 1996 onward) were included in our analysis. Standardized mortality rates were calculated for the 2010 Brazilian population. The annual trend in mortality rates was analyzed by joinpoint regression. We calculated risk ratios (RRs) by age group, time period of death, and gender, using a person-years denominator. Results: A total of 32,092 deaths were recorded in the study period. Standardized mortality rates trended upward, rising from 0.24/100,000 population in 1979 to 1.10/100,000 population in 2014. The annual upward trend in mortality rates had two inflection points, in 1992 and 2008, separating three distinct time segments with an annual growth of 2.2%, 6.8%, and 2.4%, respectively. The comparison of RRs for the age groups, using the 50- to 54-year age group as a reference, and for the study period, using 1979-1984 as a reference, were 16.14 (14.44-16.36) and 6.71 (6.34-7.12), respectively. Men compared with women had higher standardized mortality rates (per 100,000 person-years) in all age groups. Conclusion: Brazilian IPF mortality rates are lower than those of other countries, suggesting underdiagnosis or underreporting. The temporal trend is similar to those reported in the literature and is not explained solely by population aging.

BACKGROUND:Brazil is an exporter of precious stones and craftsmen often work in poor conditions. We assessed silica-related diseases among crystal craftsmen and the complexity of its control.METHODS:Case-series including 118 subjects evaluated from 2006 to 2015, based on medical interviews, chest X-rays, spirometry, and respirable silica samples.RESULTS:Median age and length of exposure were 32 and 13 years, respectively. Silicosis, with 1/0 as a threshold, was diagnosed radiologically in 57 individuals (48.3%). Respirable silica concentrations were 0.9-29.3 times greater than the Brazilian occupational exposure limit. A Receiver Operating Characteristic (ROC) curve with the same diagnosis threshold showed best discrimination at a cut point of 12.5 years of exposure, corresponding to 4.85 mg-y/m3 of cumulative silica exposure. There was a significant decline in FEV1 across radiological and cumulative silica exposure categories. Eleven individuals (9.3%) had mycobacterial diseases at baseline or follow-up.CONCLUSION:Crystal craftsmen continue to suffer from silicosis, lung function impairment, comorbidity, and death due to silicosis. To date collective protection in some work sheds has not diminished silica levels. Long-term follow-up is needed to evaluate further improvements in preventive measures. Am. J. Ind. Med. 60:239-247, 2017. © 2017 Wiley Periodicals, Inc.

Objectives: The aim of the study was to evaluate the plasma levels of inflammatory mediators in subjects exposed to silica, with and without silicosis compared with unexposed control group; and to check the association between inflammatory mediators with pulmonary function, quality of life, functional capacity, and dyspnea grade. Methods: Inflammatory mediators were measured by enzyme-linked immunosorbent assay. There were 30 subjects exposed to silica and 24 control group. Results: Interleukin-6 plasma levels were higher in subjects exposed to silica with and without silicosis than in the control group. There was a positive correlation between radiological severity and the quality of life, whereas there was a negative correlation between radiological severity and pulmonary function. A negative correlation between sTNFR1 plasma level and functional capacity was found. Interleukin-10 was negatively correlated with the quality of life total score and was positively correlated with the functional capacity and pulmonary function.

Background: There are limited data on mesothelioma mortality in industrializing countries, where, at present, most of the asbestos consumption occurs.Objectives: To analyze temporal trends and to calculate mortality rates from mesothelioma and cancer of the pleura in Brazil from 2000 to 2012 and to estimate future mortality rates.Methods: We retrieved records of deaths from mesothelioma (ICD-10C45) and cancer of the pleura (ICD-10C38.4) from 2000 to 2012 in adults aged 30 years and over. Crude and age-standardized mortality rates (ASMR) were calculated. Rate ratios of mean crude mortality for selected municipalities were compared to the Brazilian rate. A regression was carried out of the annual number of deaths against asbestos consumption using a Generalized Additive Model (GAM). The best model was chosen to estimate the future burden and peak period of deaths.Results: There were 929C45 and 1379 C38.4 deaths. The ratio of men to women for C45 was 1.4. A positive trend in C45 numbers was observed in Brazil (p = 0.0012), particularly in Sao Paulo (p = 0.0004) where ASMRs presented an increasing linear trend (p = 0.0344). Selected municipalities harboring asbestos manipulation presented 3.7-11 fold rate ratios of C45 compared to Brazil. GAM presented best fits for latencies of 34 years or more. It is estimated that the peak incidence of C45 mortality will occur between 2021 and 2026.Conclusions: The observed ASMRs and the gender ratio close to 1 suggest underreporting. Even so, deaths are increasing and mesothelioma clusters were identified. Compared to industrialized countries Brazil displays a 15-20 year lag in estimated peak mesothelioma mortality which is consistent with the lag of asbestos peak consumption in the country. (C) 2015 Elsevier Ltd. All rights reserved.

Objective: To evaluate the plasma levels of CCL2, CCL3, CCL11, CCL24, tumor necrosis factor alpha, sTNFR1, and sTNFR2 in subjects exposed to silica (SES) with and without silicosis compared with unexposed reference control group, and their associations with the radiological severity and duration of exposure to silica.Methods: Fifty-seven SES; 36 with silicosis and 22 subjects in control group, were included in the study.Results: CCL3, CCL24, sTNFR1, and sTNFR2 were increased in SES and in SES with silicosis than in controls. There were no differences in the levels of CCL2, CCL11, or tumor necrosis factor alpha. The sTNFR2 level was greater in SES with silicosis than in SES without silicosis. There was a positive correlation between sTNFR1 and sTNFR2 and the radiological severity and time of exposure to silica. sTNFR2 was associated with all categories of radiological severity.Conclusion: sTNFR2 is associated with silicosis severity and early exposure to silica.

A silicose representa um importante problema de saúde pública em todo o mundo, sobretudo nos países em desenvolvimento, sendo a principal causa de invalidez entre as doenças respiratórias ocupacionais. É uma pneumoconiose fibrótica, irreversível e potencialmente fatal, causada pela inalação de poeira contendo sílica cristalina. O diagnóstico é estabelecido através da história clínica e ocupacional de exposição à sílica, na presença de alterações radiológicas. Estudos experimentais e clínicos sugerem que a inalação da poeira da sílica está associada a um processo inflamatório pulmonar e sistêmico, mesmo em indivíduos que não desenvolveram silicose. Até o momento não existem exames laboratoriais específicos para o diagnóstico da doença, de modo que o conhecimento de marcadores biológicos associados à imunopatologia da silicose pode ser importante na detecção precoce da instalação e desenvolvimento da doença. O presente artigo traz uma revisão de estudos que investigaram os possíveis biomarcadores inflamatórios da doença no sangue e no lavado bronco-alveolar de humanos e de modelos experimentais.

INTRODUÇÃO: A exploração da pedra São Thomé, na região de São Thomé das Letras-MG, é antiga e estimam-se 2.000 trabalhadores envolvidos em sua extração e beneficiamento. No entanto, a silicose entre eles não era, até recentemente, registrada de forma consistente. OBJETIVO: Delinear o perfil ocupacional e radiológico de um grupo de trabalhadores de quartzito. Métodos: Série de 46 casos provenientes de um grupo de 185 extratores e beneficiadores cujos dados ocupacionais e radiografias de tórax foram analisados em ambulatório especializado. RESULTADOS: Todos os 185 trabalhadores eram do sexo masculino, com idade média de 41,3 anos e tempo de exposição mediano de 6,1 anos. As radiografias demonstraram imagens compatíveis com silicose em 46 (24,9%) deles. A ocorrência foi maior no setor de beneficiamento, onde também ocorreram os casos mais graves, incluindo três portadores de grandes opacidades e oito com formas aceleradas da doença. Os últimos, em geral mais jovens e com menor tempo de exposição, sugerem ter sido expostos a maiores concentrações de sílica. CONCLUSÃO: Apesar das limitações do estudo, a alta frequencia de silicose encontrada no grupo sugere serem precárias as medidas de prevenção da exposição à sílica, especialmente em épocas mais recentes. Isto pode ser reflexo da mecanização intensa ocorrida nos últimos anos, portanto, ações de vigilância e prevenção devem ser priorizadas no setor.